SEC Filing :: STRATTEC Security Corp.

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Table of Contents

View:

Download DOC

Download PDF

Download XLS

Download XBRL

Form 10-Q

UNITED STATES

SECURITIES AND EXCHANGE COMMISSION

Washington, DC 20549

FORM 10-Q

x	QUARTERLY REPORT PURSUANT TO SECTION 13 OR 15(d) OF THE SECURITIES EXCHANGE ACT OF 1934

For the quarterly period ended April 1, 2012

¨	TRANSITION REPORT PURSUANT TO SECTION 13 OR 15(d) OF THE SECURITIES EXCHANGE ACT OF 1934

For the transition period from to

Commission File Number 0-25150

STRATTEC SECURITY CORPORATION

(Exact Name of Registrant as Specified in Its Charter)


Wisconsin		39-1804239
(State of Incorporation)		(I.R.S. Employer Identification No.)

3333 West Good Hope Road, Milwaukee, WI 53209

(Address of Principal Executive Offices)

(414) 247-3333

(Registrant’s Telephone Number, Including Area Code)

Indicate by check mark whether the registrant (1) has filed all reports required to be filed by Section 13 or 15(d) of the Securities Exchange Act of 1934 during the preceding 12 months (or for such shorter period that the registrant was required to file such reports), and (2) has been subject to such filing requirements for the past 90 days. YES x NO ¨

Indicate by check mark whether the registrant has submitted electronically and posted on its corporate Web site, if any, every Interactive Data File required to be submitted and posted pursuant to Rule 405 of Regulation S-T (§232.405 of this chapter) during the preceding 12 months (or for such shorter period that the registrant was required to submit and post such files). YES x NO ¨

Indicate by check mark whether the registrant is a large accelerated filer, an accelerated filer, a non-accelerated filer, or a smaller reporting company. See the definitions of “large accelerated filer,” “accelerated filer” and “smaller reporting company” in Rule 12b-2 of the Exchange Act. (Check one):


Large Accelerated filer	¨	Accelerated filer	x

Non-accelerated filer	¨ (Do not check if a smaller reporting company)	Smaller Reporting Company	¨

Indicate by check mark whether the registrant is a shell company (as defined in Rule 12b-2 of the Exchange Act). YES ¨ NO x

Indicate the number of shares outstanding of each of the issuer’s classes of common stock as of the latest practicable date.

Common stock, par value $0.01 per share: 3,303,196 shares outstanding as of April 1, 2012

STRATTEC SECURITY CORPORATION

FORM 10-Q

April 1, 2012

INDEX


		Page
Part I - FINANCIAL INFORMATION
Item 1	Financial Statements
	Condensed Consolidated Statements of Operations and Comprehensive Income	3
	Condensed Consolidated Balance Sheets	4
	Condensed Consolidated Statements of Cash Flows	5
	Notes to Condensed Consolidated Financial Statements	6-13
Item 2	Management’s Discussion and Analysis of Financial Condition and Results of Operations	14-27
Item 3	Quantitative and Qualitative Disclosures About Market Risk	28-29
Item 4	Controls and Procedures	29

Part II - OTHER INFORMATION
Item 1	Legal Proceedings	30
Item 1A	Risk Factors	30
Item 2	Unregistered Sales of Equity Securities and Use of Proceeds	30
Item 3	Defaults Upon Senior Securities	30
Item 4	Mine Safety Disclosures	30
Item 5	Other Information	30
Item 6	Exhibits	30

PROSPECTIVE INFORMATION

A number of the matters and subject areas discussed in this Form 10-Q contain “forward-looking statements” within the meaning of the Private Securities Litigation Reform Act of 1995. These statements may be identified by the use of forward-looking words or phrases such as “anticipate,” “believe,” “would,” “expect,” “intend,” “may,” “planned,” “potential,” “should,” “will,” and “could,” or the negative of these terms or words of similar meaning. These statements include expected future financial results, product offerings, global expansion, liquidity needs, financing ability, planned capital expenditures, management’s or the Company’s expectations and beliefs, and similar matters discussed in this Form 10-Q. The discussions of such matters and subject areas are qualified by the inherent risks and uncertainties surrounding future expectations generally, and also may materially differ from the Company’s actual future experience.

The Company’s business, operations and financial performance are subject to certain risks and uncertainties, which could result in material differences in actual results from the Company’s current expectations. These risks and uncertainties include, but are not limited to, general economic conditions, in particular relating to the automotive industry, consumer demand for the Company’s and its customers’ products, competitive and technological developments, customer purchasing actions, foreign currency fluctuations, fluctuations in costs of operations (including fluctuations in the cost of raw materials) and other matters described under “Risk Factors” in the Management’s Discussion and Analysis of Financial Condition and Results of Operations section of this Form 10-Q and in the section titled “Risk Factors” in the Company’s Form 10-K report filed with the Securities and Exchange Commission for the year ended July 3, 2011.

Shareholders, potential investors and other readers are urged to consider these factors carefully in evaluating the forward-looking statements and are cautioned not to place undue reliance on such forward-looking statements. The forward-looking statements made herein are only made as of the date of this Form 10-Q and the Company undertakes no obligation to publicly update such forward-looking statements to reflect subsequent events or circumstances occurring after the date of this Form 10-Q.

Item 1 Financial Statements

STRATTEC SECURITY CORPORATION AND SUBSIDIARIES

Condensed Consolidated Statements of Operations and Comprehensive Income

(In Thousands, Except Per Share Amounts; Unaudited)


	Three Months Ended						Nine Months Ended
	April 1, 2012			March 27, 2011			April 1, 2012			March 27, 2011
Net sales	$	70,608		$	65,650		$	202,871		$	186,711
Cost of goods sold		57,556			56,531			167,075			157,466

Gross profit		13,052			9,119			35,796			29,245
Engineering, selling and administrative expenses		8,720			7,953			24,907			24,436

Income from operations		4,332			1,166			10,889			4,809
Interest income		15			36			47			84
Equity (loss) earnings of joint ventures		(140	)		197			(452	)		1,000
Interest expense – related parties		(19	)		(38	)		(73	)		(134	)
Other income (expense), net		662			(357	)		297			(101	)

Income before provision for income taxes		4,850			1,004			10,708			5,658
Provision for income taxes		1,136			262			2,717			1,394

Net income		3,714			742			7,991			4,264
Net income attributed to non-controlling interest		(986	)		(687	)		(2,433	)		(1,544	)

Net income attributable to STRATTEC SECURITY CORPORATION	$	2,728		$	55		$	5,558		$	2,720

Comprehensive Income:
Net income	$	3,714		$	742		$	7,991		$	4,264
Change in cumulative translation adjustments, net		1,371			595			(1,274	)		1,125

Comprehensive income		5,085			1,337			6,717			5,389
Comprehensive income attributed to non-controlling interest		(1,025	)		(700	)		(2,391	)		(1,566	)

Comprehensive income attributable to STRATTEC SECURITY CORPORATION	$	4,060		$	637		$	4,326		$	3,823

Earnings Per Share:
Basic	$	0.83		$	0.02		$	1.68		$	0.83

Diluted	$	0.82		$	0.02		$	1.67		$	0.82

Average Shares Outstanding:
Basic		3,303			3,286			3,299			3,284
Diluted		3,333			3,339			3,329			3,322
Cash dividends declared per share	$	0.10		$	—		$	0.30		$	1.20

The accompanying notes are an integral part of these condensed consolidated statements of operations and comprehensive income.

STRATTEC SECURITY CORPORATION AND SUBSIDIARIES

Condensed Consolidated Balance Sheets

(In Thousands, Except Share Amounts)


	April 1, 2012			July 3, 2011
	(Unaudited)
ASSETS
Current Assets:
Cash and cash equivalents	$	15,664		$	17,250
Receivables, net		41,591			39,649
Inventories-
Finished products		7,435			5,899
Work in process		5,737			5,557
Purchased materials		11,191			11,879
Excess and obsolete reserve		(1,304	)		(1,200	)

Inventories, net		23,059			22,135
Other current assets		17,366			15,368

Total current assets		97,680			94,402
Deferred income taxes		3,667			3,639
Investment in joint ventures		8,890			7,276
Loan to joint venture		—			1,500
Other long-term assets		560			635
Property, plant and equipment		148,831			141,364
Less: accumulated depreciation		(104,406	)		(100,728	)

Net property, plant and equipment		44,425			40,636

		$155,222		$	148,088

LIABILITIES AND SHAREHOLDERS’ EQUITY
Current Liabilities:
Accounts payable	$	24,373		$	22,851
Loans from related parties		1,000			1,850
Accrued Liabilities:
Payroll and benefits		14,921			15,546
Environmental reserve		1,442			1,478
Warranty		4,323			3,856
Other		7,189			5,407

Total current liabilities		53,248			50,988
Accrued pension obligations		2,659			3,447
Accrued postretirement obligations		2,755			3,589
Other long-term liabilities		85			—
Shareholders’ Equity:
Common stock, authorized 12,000,000 shares, $.01 par value, issued 6,932,457 shares at April 1, 2012 and 6,920,557 shares at July 3, 2011		69			69
Capital in excess of par value		80,438			79,767
Retained earnings		168,690			164,138
Accumulated other comprehensive loss		(22,982	)		(21,750	)
Less: treasury stock, at cost (3,629,261 shares at April 1, 2012 and 3,631,079 shares at July 3, 2011)		(135,980	)		(136,009	)

Total STRATTEC SECURITY CORPORATION shareholders’ equity		90,235			86,215
Non-controlling interest		6,240			3,849

Total shareholders’ equity		96,475			90,064

	$	155,222		$	148,088

The accompanying notes are an integral part of these condensed consolidated balance sheets.

STRATTEC SECURITY CORPORATION AND SUBSIDIARIES

Condensed Consolidated Statements of Cash Flows

(In Thousands)

(Unaudited)


	Nine Months Ended
	April 1, 2012			March 27, 2011
CASH FLOWS FROM OPERATING ACTIVITIES:
Net income	$	7,991		$	4,264
Adjustments to reconcile net income to net cash provided by (used in) operating activities:
Depreciation and amortization		5,083			4,904
Foreign currency transaction (gain) loss		(907	)		558
Stock based compensation expense		622			453
Equity loss (earnings) of joint ventures		452			(1,000	)
Unrealized loss on foreign currency option contracts		542			114
Change in operating assets and liabilities:
Receivables		(2,263	)		(6,276	)
Inventories		(924	)		(6,345	)
Other assets		(2,600	)		(1,308	)
Accounts payable and accrued liabilities		1,851			4,279
Other, net		6			49

Net cash provided by (used in) operating activities		9,853			(308	)
CASH FLOWS FROM INVESTING ACTIVITIES:
Investment in joint ventures		(200	)		(300	)
Purchase of additional interest in majority owned subsidiary		—			(22	)
Restricted cash		—			2,100
Purchase of property, plant and equipment		(9,585	)		(5,727	)
Proceeds from sale of property, plant and equipment		9			21

Net cash used in investing activities		(9,776	)		(3,928	)
CASH FLOWS FROM FINANCING ACTIVITIES:
Dividends paid		(1,006	)		(3,989	)
Exercise of stock options and employee stock purchases		74			44
Repayment of loan from related parties		(850	)		(850	)

Net cash used in financing activities		(1,782	)		(4,795	)
Foreign currency impact on cash		119			(156	)

NET DECREASE IN CASH AND CASH EQUIVALENTS		(1,586	)		(9,187	)
CASH AND CASH EQUIVALENTS
Beginning of period		17,250			21,867

End of period	$	15,664		$	12,680

SUPPLEMENTAL DISCLOSURE OF CASH FLOW INFORMATION:
Income taxes paid	$	1,910		$	1,526
Interest paid – related parties		96			147

The accompanying notes are an integral part of these condensed consolidated statements of cash flows.

On March 30, 2012, a non-cash event was recorded whereby the outstanding loan to joint venture principal and accrued interest amounts of $1.5 million and $112,000, respectively, were terminated and converted to additional capital contributions in the joint venture investment.

STRATTEC SECURITY CORPORATION AND SUBSIDIARIES

Notes to Condensed Consolidated Financial Statements

(Unaudited)

Basis of Financial Statements

STRATTEC SECURITY CORPORATION designs, develops, manufactures and markets automotive access control products, including mechanical locks and keys, electronically enhanced locks and keys, steering column and instrument panel ignition lock housings, latches, power sliding door systems, power lift gate systems, power deck lid systems, door handles and related products for primarily North American automotive customers. We also supply global automotive manufacturers through a unique strategic relationship with WITTE Automotive of Velbert, Germany, and ADAC Automotive of Grand Rapids, Michigan. Under this relationship, STRATTEC, WITTE and ADAC market our products to global customers under the “VAST” brand name (as more fully described herein). STRATTEC products are shipped to customer locations in the United States, Canada, Mexico, Europe, South America, Korea and China, and we provide full service and aftermarket support for our products.

The accompanying condensed consolidated financial statements reflect the consolidated results of STRATTEC SECURITY CORPORATION, its wholly owned Mexican subsidiary, STRATTEC de Mexico, and its majority owned subsidiaries, ADAC-STRATTEC, LLC and STRATTEC POWER ACCESS LLC. STRATTEC SECURITY CORPORATION is located in Milwaukee, Wisconsin. STRATTEC de Mexico is located in Juarez, Mexico. ADAC-STRATTEC, LLC and STRATTEC POWER ACCESS LLC have operations in El Paso, Texas and Juarez, Mexico. Equity investments in Vehicle Access Systems Technology LLC (“VAST LLC”) for which we exercise significant influence but do not control and are not the primary beneficiary, are accounted for using the equity method. VAST LLC consists primarily of three wholly owned subsidiaries in China and one joint venture in Brazil. We have only one reporting segment.

In the opinion of management, the accompanying condensed consolidated balance sheet as of July 3, 2011, which has been derived from our audited financial statements, and the related unaudited interim condensed consolidated financial statements contain all adjustments, consisting only of normal recurring items, necessary for their fair presentation in conformity with accounting principles generally accepted in the United States of America (“U.S. GAAP”) and in accordance with Rule 10-01 of Regulation S-X. All significant intercompany transactions have been eliminated.

Interim financial results are not necessarily indicative of operating results for an entire year. The information included in this Form 10-Q should be read in conjunction with Management’s Discussion and Analysis and the financial statements and notes thereto included in the STRATTEC SECURITY CORPORATION 2011 Annual Report, which was filed with the Securities and Exchange Commission as an exhibit to our Form 10-K on September 8, 2011.

Derivative Instruments

We own and operate manufacturing operations in Mexico. As a result, a portion of our manufacturing costs are incurred in Mexican pesos, which causes our earnings and cash flows to fluctuate as a result of changes in the U.S. dollar / Mexican peso exchange rate. Beginning in January 2011, we entered into agreements with Bank of Montreal that provide for two weekly Mexican peso currency option contracts for a portion of our weekly estimated peso denominated operating costs. Current contracts with Bank of Montreal extend through June 28, 2013. The two weekly option contracts are for equivalent notional amounts. The contracts that are currently effective and expire July 6, 2012 provide for the purchase of Mexican pesos at a U.S. dollar / Mexican peso exchange rate of 11.85 if the spot rate at the weekly expiry date is below 11.85 or for the purchase of Mexican pesos at a U.S. dollar / Mexican peso exchange rate of 12.85 if the spot rate at the weekly expiry date is above 12.85. Additional contracts that are effective July 6, 2012 through June 28, 2013 provide for the purchase of Mexican pesos at an average U.S. dollar / Mexican peso exchange rate of 12.40 if the spot rate at the weekly expiry date is below an average of 12.40 or for the purchase of Mexican pesos at an average U.S. dollar / Mexican peso exchange rate of 13.40 if the spot rate at the weekly expiry date is above an average of 13.40. Our objective in entering into these currency option contracts is to minimize our earnings volatility resulting from changes in exchange rates affecting the U.S. dollar cost of our Mexican operations. The Mexican peso option contracts are not used for speculative purposes and are not designated as hedges, and as a result, all currency option contracts are recognized in our accompanying condensed consolidated financial statements at fair value and changes in the fair value of the currency option contracts are reported in current earnings as part of Other Income (Expense), net. The premiums to be paid and received under the weekly Mexican peso currency option contracts net to zero, and as a result, premiums related to the contracts did not impact our earnings.

The following table quantifies the outstanding Mexican peso currency option contracts as of April 1, 2012 (thousands of dollars):


	Effective Dates	Notional Amount		Average Option Contractual Exchange Rate		Fair Value
Buy MXP/Sell USD	April 2, 2012-July 6, 2012	$	3,785		11.85	$	2
Buy MXP/Sell USD	April 2, 2012-July 6, 2012	$	3,785		12.85	$	(73	)
Buy MXP/Sell USD	July 6, 2012 – June 28, 2013	$	10,200		12.40	$	176
Buy MXP/Sell USD	July 6, 2012 – June 28, 2013	$	10,200		13.40	$	(402	)

The fair market value of all outstanding Mexican peso option contracts in the accompanying Condensed Consolidated Balance Sheets was as follows (thousands of dollars):


	April 1, 2012			July 3, 2011
Not Designated as Hedging Instruments:
Other Current Assets:
Mexican Peso Option Contracts	$	—		$	245
Other Current Liabilities:
Mexican Peso Option Contracts	$	(212	)	$	—
Other Long-Term Liabilities
Mexican Peso Option Contracts	$	(85	)	$	—

The pre-tax effects of the Mexican peso option contracts on the accompanying Condensed Consolidated Statements of Operations and Comprehensive Income for the three and nine months ended April 1, 2012 and March 27, 2011 consisted of the following (thousands of dollars):


	Other Income (Expense), net
	Three Months Ended						Nine Months Ended
	April 1, 2012			March 27, 2011			April 1, 2012			March 27, 2011
Not Designated as Hedging Instruments:
Realized Gain	$	—		$	—		$	18		$	—
Realized (Loss)	$	(48	)	$	—		$	(254	)	$	—
Unrealized Gain (Loss)	$	1,174		$	(114	)	$	(542	)	$	(114	)

Fair Value of Financial Instruments

The fair value of our cash and cash equivalents, accounts receivable, accounts payable and loans from related parties approximated book value as of April 1, 2012 and March 27, 2011. Fair value is defined as the exchange price that would be received for an asset or paid for a liability in the principal or most advantageous market in an orderly transaction between market participants on the measurement date. The following table summarizes our financial assets and liabilities measured at fair value on a recurring basis as of April 1, 2012 (in thousands of dollars):


	Fair Value Inputs
	Quoted Prices In Active Markets		Observable Inputs Other Than Market Prices		Unobservable Inputs
Assets:
Rabbi Trust Assets:
Stock Index Funds:
Small Cap	$	308	$	—	$	—
Mid Cap		298		—		—
Large Cap		829		—		—
U.S. Treasury Securities		2,516		—		—
Cash and Cash Equivalents		461		—		—
Mexican Peso Option Contracts		—		178		—

Total Assets at Fair Value	$	4,412	$	178	$	—

Liabilities:
Mexican Peso Option Contracts	$	—	$	475	$	—

The Rabbi Trust assets fund our supplemental executive retirement plan and are included in Other Current Assets in the accompanying Condensed Consolidated Balance Sheets. The Rabbi Trust assets are classified as Level 1 assets. Refer to the discussion of Mexican peso option contracts under Derivative Instruments above. The fair value of the Mexican Peso option contracts are based on an option pricing model that considers the remaining term, current exchange rate and volatility of the underlying foreign currency base. There were no transfers between Level 1 and Level 2 assets during the three and nine months ended April 1, 2012.

Equity (Loss) Earnings of Joint Ventures

We hold a one-third interest in a joint venture company, Vehicle Access Systems Technology LLC (“VAST LLC”), with WITTE Automotive of Velbert, Germany (“WITTE”), and ADAC Automotive of Grand Rapids, Michigan (“ADAC”). VAST LLC exists to seek opportunities to manufacture and sell all three companies’ products in areas of the world outside of North America and Europe. VAST LLC consists primarily of three wholly owned subsidiaries in China and one joint venture in Brazil. Our investment in VAST LLC, for which we exercise significant influence but do not control and are not the primary beneficiary, is accounted for using the equity method. The following are summarized statements of operations for VAST LLC (thousands of dollars):


	Three Months Ended					Nine Months Ended
	April 1, 2012			March 27, 2011		April 1, 2012			March 27, 2011
Net Sales	$	20,882		$	18,543	$	59,293		$	56,196
Cost of Goods Sold		17,545			15,431		50,681			45,738

Gross Profit		3,337			3,112		8,612			10,458
Engineering, Selling and Administrative
Expenses		4,162			2,439		11,507			7,559

(Loss) Income from Operations		(825	)		673		(2,895	)		2,899
Other Income (Expense), net		299			298		1,318			962

(Loss) Income Before Provision for
Income Taxes		(526	)		971		(1,577	)		3,861
(Benefit) Provision for Income Taxes		(108	)		387		(205	)		865

Net (Loss) Income	$	(418	)	$	584	$	(1,372	)	$	2,996

STRATTEC’s Share of VAST LLC
Net (Loss) Income	$	(139	)	$	195	$	(457	)	$	999
Intercompany Profit Eliminations		(1	)		2		5			1

STRATTEC’s Equity (Loss) Earnings of Joint Ventures	$	(140	)	$	197	$	(452	)	$	1,000

Loan to Joint Venture

Effective November 20, 2009, VAST LLC purchased the 40 percent non-controlling interest owned by its former partners in the joint ventures in China. Initially, a loan of $2.5 million was made from each partner, STRATTEC, WITTE and ADAC, to fund a portion of the purchase price. In December 2009, $1 million of each partner’s loan balance was repaid. As of March 30, 2012, each partners’ outstanding principal and accrued interest under the loan totaled $1.5 million and $112,000, respectively. These outstanding amounts were terminated and converted to additional capital contributions by each partner in VAST LLC effective as of March 30, 2012.

Environmental Reserve

In 1995, we recorded a provision of $3 million for estimated costs to remediate an environmental contamination site at our Milwaukee facility. The site was contaminated by a solvent spill, which occurred in 1985, from a former above ground solvent storage tank located on the east side of the facility. The reserve was originally established based on third party estimates to adequately cover the cost for active remediation of the contamination. Due to changing technology and related costs associated with active remediation of the contamination, an updated analysis and estimate was obtained during fiscal 2010. As a result of this analysis, the reserve was reduced by approximately $1.1 million, to $1.5 million at December 27, 2009, to reflect the revised monitoring and remediation cost estimate. From 1995 through April 1, 2012, costs of approximately $430,000 have been incurred related to the installation of monitoring wells on the property and ongoing monitoring costs. We continue to monitor and evaluate the site with the use of groundwater monitoring wells that are installed on the property. An environmental consultant samples these wells one or two times a year to determine the status of the contamination and the potential for remediation of the contamination by natural attenuation, the dissipation of the contamination over time to concentrations below applicable standards. If such sampling evidences a sufficient degree of and trend toward natural attenuation of the contamination, we may be able to obtain a closure letter from the regulatory authorities resolving the issue without the need for active remediation. If a sufficient degree and trend toward natural attenuation is not evidenced by sampling, a more active form of remediation beyond natural attenuation may be required. The sampling has not yet satisfied all of the requirements for closure by natural attenuation. As a result, sampling continues and the reserve remains at an amount to reflect the current estimated cost of active remediation. The reserve is not measured on a discounted basis. We believe, based on findings-to-date and known environmental regulations, that the environmental reserve of $1.4 million at April 1, 2012, is adequate.

Shareholders’ Equity

A summary of activity impacting shareholders’ equity for the nine month period ended April 1, 2012 is as follows (in thousands):


	Total Shareholders’ Equity			Equity Attributed to STRATTEC			Equity Attributed to Non-Controlling Interest
Balance, July 3, 2011	$	90,064		$	86,215		$	3,849
Net Income		7,991			5,558			2,433
Dividend Declared		(1,006	)		(1,006	)		—
Translation adjustments		(1,274	)		(1,232	)		(42	)
Stock Based Compensation		622			622			—
Tax Benefit – Dividend Paid on Restricted Shares		5			5			—
Employee Stock Purchases and Stock Option Exercises		73			73			—

Balance, April 1, 2012	$	96,475		$	90,235		$	6,240

Other Income (Expense), net

Net other income (expense) included in the accompanying Condensed Consolidated Statements of Operations and Comprehensive Income primarily includes foreign currency transaction gains and losses, unrealized gains and losses on our Mexican Peso option contracts, and Rabbi Trust gains and losses. Foreign currency transaction gains and losses are the result of foreign currency transactions entered into by our Mexican subsidiaries and fluctuations in foreign currency cash balances. We entered into the Mexican Peso currency option contracts to minimize earnings volatility resulting from changes in exchange rates affecting the U.S. dollar cost of our Mexican operations. The Rabbi Trust funds our supplemental executive retirement plan. The investments held in the Trust are considered trading securities. The impact of these items for each of the periods presented is as follows (in thousands):


	Three Months Ended						Nine Months Ended
	April 1, 2012			March 27, 2011			April 1, 2012			March 27, 2011
Foreign Currency Transaction (Loss) Gain	$	(698	)	$	(368	)	$	907		$	(558	)
Rabbi Trust Gain		161			75			64			333
Unrealized Gain (Loss) on Mexican Peso Option Contracts		1,174			(114	)		(542	)		(114	)
Realized Loss on Mexican Peso Option Contracts, net		(48	)		—			(236	)		—
Other		73			50			104			238

	$	662		$	(357	)	$	297		$	(101	)

Income Taxes

The income tax provisions for the three and nine month periods ended April 1, 2012 and March 27, 2011 are impacted by a lower effective and statutory tax rate for income subject to tax in Mexico as compared to the effective and statutory tax rate for income subject to tax in the U.S. We are currently subject to a U.S. Federal income tax examination related to fiscal 2009.

Earnings Per Share (EPS)

Basic earnings per share is computed on the basis of the weighted average number of shares of common stock outstanding during the applicable period. Diluted earnings per share is computed on the basis of the weighted average number of shares of common stock plus the potential dilutive common shares outstanding during the applicable period using the treasury stock method. Potential dilutive common shares include outstanding stock options and restricted stock awards. A reconciliation of the components of the basic and diluted per-share computations follows (in thousands, except per share amounts):


	Three Months Ended
	April 1, 2012						March 27, 2011
	Net Income Attributable to STRATTEC		Weighted Average Shares		Per-Share Amount		Net Income Attributable to STRATTEC		Weighted Average Shares		Per-Share Amount
Basic Earnings Per Share	$	2,728		3,303	$	0.83	$	55		3,286	$	0.02

Stock-Based Compensation				30						53

Diluted Earnings Per Share	$	2,728		3,333	$	0.82	$	55		3,339	$	0.02


	Nine Months Ended
	April 1, 2012						March 27, 2011
	Net Income Attributable to STRATTEC		Weighted Average Shares		Per-Share Amount		Net Income Attributable to STRATTEC		Weighted Average Shares		Per-Share Amount
Basic Earnings Per Share	$	5,558		3,299	$	1.68	$	2,720		3,284	$	0.83

Stock-Based Compensation				30						38

Diluted Earnings Per Share	$	5,558		3,329	$	1.67	$	2,720		3,322	$	0.82

Net earnings available to participating securities were not significant for the three and nine months ended April 1, 2012 and March 27, 2011. We consider restricted stock that provides the holder with a non-forfeitable right to receive dividends to be a participating security.

As of April 1, 2012, options to purchase 248,000 shares of common stock at a weighted-average exercise price of $33.75 were excluded from the calculation of diluted earnings per share because their inclusion would have been anti-dilutive. As of March 27, 2011, options to purchase 90,000 shares of common stock at a weighted-average exercise price of $56.29 were excluded from the calculation of diluted earnings per share because their inclusion would have been anti-dilutive.

Stock-based Compensation

We maintain an omnibus stock incentive plan. This plan provides for the granting of stock options, shares of restricted stock and stock appreciation rights. The Board of Directors has designated 1,700,000 shares of common stock available for the grant of awards under the plan. Remaining shares available to be granted under the plan as of April 1, 2012 were 170,743. Awards that expire or are canceled without delivery of shares become available for re-issuance under the plan. We issue new shares of common stock to satisfy stock option exercises.

Nonqualified and incentive stock options and shares of restricted stock have been granted to our officers, outside directors and specified employees under our stock incentive plan. Stock options granted under the plan may not be issued with an exercise price less than the fair market value of the common stock on the date the option is granted. Stock options become exercisable as determined at the date of grant by the Compensation Committee of the Board of Directors. The options expire 5 to 10 years after the grant date unless an earlier expiration date is set at the time of grant. The options vest 1 to 4 years after the date of grant. Shares of restricted stock granted under the plan are subject to vesting criteria determined by the Compensation Committee of the Board of Directors at the time the shares are granted and have a minimum vesting period of three years from the date of grant. Restricted shares granted have voting and dividend rights, regardless if the shares are vested or unvested. The restricted stock grants issued to date vest 3 years after the date of grant.

The fair value of each stock option grant was estimated as of the date of grant using the Black-Scholes pricing model. The resulting compensation cost for fixed awards with graded vesting schedules is amortized on a straight line basis over the vesting period for the entire award. The fair value of each restricted stock grant was based on the market price of the underlying common stock as of the date of grant. The resulting compensation cost is amortized on a straight line basis over the vesting period.

A summary of stock option activity under our stock incentive plan for the nine months ended April 1, 2012 is as follows:


	Shares			Weighted Average Exercise Price		Weighted Average Remaining Contractual Term (years)		Aggregate Intrinsic Value (in thousands)
Outstanding, July 3, 2011		297,400		$	28.32
Granted		40,000		$	26.53
Exercised		(2,600	)	$	10.92
Expired		(2,000	)	$	37.58
Forfeited		—			—

Outstanding, April 1, 2012		332,800		$	28.19		5.6	$	1,465

Exercisable, April 1, 2012		192,700		$	33.69		4.7	$	949

The intrinsic value of stock options exercised and the fair value of stock options vesting during the three and nine month periods presented is as follows (in thousands):


	Three Months Ended				Nine Months Ended
	April 1, 2012		March 27, 2011		April 1, 2012		March 27, 2011
Intrinsic Value of Options Exercised	$	—	$	—	$	25	$	—
Fair Value of Stock Options Vesting	$	71	$	125	$	268	$	293

The grant date fair value and assumptions used to determine compensation expense for the options granted during each period presented were as follows:


	Nine Months Ended
	April 1, 2012			March 27, 2011
Weighted Average Grant Date Fair Value:
Options Issued at Grant Date Market Value		n/a			n/a
Options Issued Above Grant Date Market Value	$	10.29		$	7.48
Assumptions:
Risk Free Interest Rate		1.23	%		1.08	%
Expected Volatility		59.88	%		59.89	%
Expected Dividend Yield		1.74	%		1.54	%
Expected Term (in years)		6.0			4.0

A summary of restricted stock activity under our omnibus stock incentive plan for the nine months ended April 1, 2012 is as follows:


	Shares			Weighted Average Grant Date Fair Value
Nonvested Balance, July 3, 2011		38,900		$	21.19
Granted		20,000		$	23.01
Vested		(9,300	)	$	29.00
Forfeited		(200	)	$	23.01

Nonvested Balance, April 1, 2012		49,400		$	20.45

As of April 1, 2012, there was $817,000 of total unrecognized compensation cost related to stock options granted under our omnibus stock incentive plan. This cost is expected to be recognized over a weighted average period of 11 months. As of April 1, 2012, there was approximately $547,000 of total unrecognized compensation cost related to restricted stock grants under the plan. This cost is expected to be recognized over a weighted average period of 1 year. Total unrecognized compensation cost will be adjusted for any future changes in estimated and actual forfeitures of awards granted under the plan.

Pension and Other Postretirement Benefits

We have a qualified, noncontributory defined benefit pension plan covering substantially all U.S. associates. Benefits are based on years of service and final average compensation. Our policy is to fund at least the minimum actuarially computed annual contribution required under the Employee Retirement Income Security Act of 1974 (ERISA). Plan assets consist primarily of listed equity and fixed income securities. Effective January 1, 2010, an amendment to the qualified defined benefit pension plan discontinued the benefit accruals for salary increases and credited service rendered after December 31, 2009.

We have a noncontributory supplemental executive retirement plan (“SERP”), which is a nonqualified defined benefit plan that essentially mirrors the qualified plan, but provides benefits in excess of certain limits placed on our qualified retirement plan by the Internal Revenue Code. The SERP will pay supplemental pension benefits to certain key employees upon retirement based upon the employees’ years of service and compensation. The SERP is being funded through a Rabbi trust with M&I Trust Company. We also sponsor a postretirement health care plan for all of our U.S. associates hired prior to June 2, 2001. The expected cost of retiree health care benefits is recognized during the years that the associates who are covered under the plan render service. Effective January 1, 2010, an amendment to the postretirement health care plan limited the benefit for future eligible retirees to $4,000 per plan year and is subject to a maximum coverage period based on the associate’s retirement date and age. The postretirement health care plan is unfunded.

The following tables summarize the net periodic benefit cost recognized for each of the periods indicated under these two plans (in thousands):


	Pension Benefits						Postretirement Benefits
	Three Months Ended						Three Months Ended
	April 1, 2012			March 27, 2011			April 1, 2012			March 27, 2011
Service cost	$	37		$	17		$	3		$	2
Interest cost		1,196			1,151			56			67
Expected return on plan assets		(1,603	)		(1,580	)		—			—
Amortization of prior service cost		3			3			(191	)		(187	)
Amortization of unrecognized net loss		604			615			168			159

Net periodic benefit cost	$	237		$	206		$	36		$	41


	Pension Benefits						Postretirement Benefits
	Nine Months Ended						Nine Months Ended
	April 1, 2012			March 27, 2011			April 1, 2012			March 27, 2011
Service cost	$	112		$	51		$	8		$	7
Interest cost		3,588			3,453			170			202
Expected return on plan assets		(4,808	)		(4,742	)		—			—
Amortization of prior service cost		9			9			(573	)		(562	)
Amortization of unrecognized net loss		1,811			1,843			505			475

Net periodic benefit cost	$	712		$	614		$	110		$	122

Voluntary contributions made to the qualified pension plan totaled $1.5 million during each of the nine month periods ending April 1, 2012 and March 27, 2011. Voluntary contributions made to date during the fourth quarter of fiscal 2012 totaled $500,000. No additional voluntary contributions are anticipated to be made during the remainder of fiscal 2012.

Item 2

STRATTEC SECURITY CORPORATION AND SUBSIDIARIES

MANAGEMENT’S DISCUSSION AND ANALYSIS

OF FINANCIAL CONDITION AND RESULTS OF OPERATIONS

The following Management’s Discussion and Analysis should be read in conjunction with STRATTEC SECURITY CORPORATION’s accompanying Condensed Consolidated Financial Statements and Notes thereto and its 2011 Annual Report which was filed with the Securities and Exchange Commission as an exhibit to its Form 10-K on September 8, 2011. Unless otherwise indicated, all references to years refer to fiscal years.

Analysis of Results of Operations

Three months ended April 1, 2012 compared to the three months ended March 27, 2011


	Three Months Ended
	April 1, 2012		March 27, 2011
Net Sales (in millions)	$	70.6	$	65.7

Based on the timing of our quarter end and a one week holiday shutdown during the prior year quarter, the current quarter included 13 customer shipping weeks while the prior year quarter included 12 customer shipping weeks. The impact of one additional week of customer shipments during the current year quarter increased sales over the prior year quarter by approximately $2.7 million. In addition, the prior year quarter net sales were reduced by $650,000 resulting from an adjustment we made in connection with certain agreed upon customer price concessions. Aggregate sales to our largest customers overall increased in the current quarter compared to the prior year quarter levels primarily due to increased customer vehicle production volumes. Higher content on certain products we supply also contributed to the net sales improvement during the quarter. Sales to each of our largest customers in the current year quarter and prior year quarter were as follows (in millions):


	Three Months Ended
	April 1, 2012			March 27, 2011
Chrysler Group LLC	$	23.6		$	21.6
General Motors Company	$	16.8		$	14.8
Ford Motor Company	$	8.4		$	7.0
Hyundai / Kia	$	3.6		$	4.0

	Three Months Ended
	April 1, 2012			March 27, 2011
Gross Profit as a Percentage of Net Sales		18.5	%		13.9	%

The higher gross profit margin in the current year quarter was primarily the result of favorable customer vehicle production volumes which resulted in more favorable absorption of fixed manufacturing costs and a favorable Mexican Peso to U.S. dollar exchange rate which positively affected the U.S. dollar cost of our Mexican operations in the current year quarter. These favorable impacts were partially offset by higher expense provisions for the accrual of bonuses earned under our Economic Value Added (EVA^®) Incentive Bonus Plans. The prior year quarter gross profit margins were also negatively impacted by a $650,000 adjustment we made in connection with certain agreed upon customer price concessions and $1.15 million in costs related to our share of the cost associated with a customer’s specific warranty claim involving our product. The average U.S. dollar/Mexican peso exchange rate increased to approximately 12.91 pesos to the dollar in the current year quarter from approximately 12.17 pesos to the dollar in the prior year quarter. This resulted in decreased U.S. dollar costs related to our Mexican operations of approximately $469,000 in the current year quarter compared to the prior year quarter.

Engineering, selling and administrative expenses were $8.7 million in the current year quarter compared to $8.0 million in the prior year quarter. The increase in these expenses was primarily driven by the higher expense provisions for the accrual of bonuses earned under our EVA^® Incentive Bonus Plans in the current year quarter as compared to the prior year quarter.

Income from operations in the current year quarter was $4.3 million compared to $1.2 million in the prior year quarter. This change was the result of the increase in sales and gross profit margin in the current year quarter over the prior year quarter as discussed above.

Equity loss of joint ventures was $140,000 during the current year quarter compared to equity earnings of joint ventures of $197,000 in the prior year quarter. During the current year quarter our joint ventures in China and Brazil continued to incur relocation costs associated with moves to new facilities and start-up costs associated with a new product line. Both of these items resulted in STRATTEC incurring an equity loss from joint ventures in the current year quarter compared to the prior year quarter in which STRATTEC had equity earnings from joint ventures. We anticipate these transition costs and related losses to continue for VAST China over the remaining 2012 calendar year.

Included in other income (expense), net in the current year quarter and prior year quarter were the following items (in thousands):


	Three Months Ended
	April 1, 2012			March 27, 2011
Foreign Currency Transaction Loss	$	(698	)	$	(368	)
Rabbi Trust Gain		161			75
Unrealized Gain (Loss) on Mexican Peso
Option Contracts		1,174			(114	)
Realized Loss on Mexican Peso
Option Contracts		(48	)		—
Other		73			50

	$	662		$	(357	)

Foreign currency transaction losses resulted from foreign currency transactions entered into by our Mexican subsidiaries and fluctuations in foreign currency cash balances. In the current quarter, the Mexican peso appreciated significantly to the U.S. dollar creating unrealized gains on our Mexican peso currency option contracts while realized losses were generated on the weekly commitments due under the contracts. Our objective in entering into these currency option contracts was to minimize our earnings volatility resulting from changes in exchange rates affecting the U.S. dollar cost of our Mexican operations. Unrealized losses recognized as a result of mark-to-market adjustments as of April 1, 2012 totaled approximately $297,000, all of which may or may not be realized, depending upon the actual Mexican peso to U.S. dollar exchange rates experienced during the balance of the contract period. Our Rabbi Trust funds our supplemental executive retirement plan. The investments held in the Trust are considered trading securities.

Our income tax provision for each of the three month periods ended April 1, 2012 and March 27, 2011 was impacted by a lower effective and statutory tax rate for income subject to tax in Mexico as compared to the effective and statutory tax rate for income subject to tax in the U.S.

Nine months ended April 1, 2012 compared to the nine months ended March 27, 2011


	Nine Months Ended
	April 1, 2012		March 27, 2011
Net Sales (in millions)	$	202.9	$	186.7

Aggregate sales to our largest customers overall increased in the current year-to-date period compared to the prior year-to-date period levels primarily due to increased customer vehicle production volumes. Higher content in certain products we supply also contributed to the net sales improvement in the current year-to-date period as compared to the prior year-to-date period. Sales to each of our largest customers in the current year-to-date and prior year-to-date periods were as follows (in millions):


	Nine Months Ended
	April 1, 2012		March 27, 2011
Chrysler Group LLC	$	65.8	$	58.8
General Motors Company	$	47.2	$	46.1
Ford Motor Company	$	24.8	$	18.6
Hyundai / Kia	$	11.1	$	11.8

Included in the prior year period sales to General Motors were $3.0 million of sales to Nexteer Automotive, formerly a unit of Delphi Corporation, which was owned by General Motors through December 2, 2010. Prior year-to-date period sales to Nexteer Automotive subsequent to December 2, 2010 totaled $2.3 million. Sales to Nexteer Automotive in the current year-to-date period totaled $4.3 million. The prior year-to-date period net sales were reduced by $650,000 resulting from an adjustment for certain agreed upon customer price concessions.


	Nine Months Ended
	April 1, 2012			March 27, 2011
Gross Profit as a Percentage of Net Sales		17.6	%		15.7	%

The higher gross profit margin in the current year period was primarily the result of favorable customer vehicle production volumes which resulted in more favorable absorption of fixed manufacturing costs and a favorable Mexican Peso to U.S. dollar exchange rate affecting the U.S. dollar cost of our Mexican operations, which positive factors were partially offset by a less favorable product content sales mix and higher purchased raw material costs for zinc and brass in the current year-to-date period. The prior year-to-date period gross profit margins were also negatively impacted by a $650,000 adjustment we made in connection with certain agreed upon customer price concessions and $1.15 million in costs related to our share of the cost associated with a customer’s specific warranty claim involving our product. The average U.S. dollar/Mexican peso exchange rate increased to approximately 13.00 pesos to the dollar in the current year period from approximately 12.45 pesos to the dollar in the prior year period. This resulted in decreased U.S. dollar costs related to our Mexican operations of approximately $970,000 in the current year-to-date period compared to the prior year-to-date period. The average zinc price paid per pound increased to $1.07 in the current year-to-date period from $1.00 in the prior year-to-date period. We have negotiated raw material price adjustment clauses with certain, but not all, of our customers to offset some of the market price fluctuations in the cost of zinc. During the current year-to-date period, we used approximately 8.0 million pounds of zinc. Increased zinc costs, net of raw material price adjustments received from certain customers, totaled approximately $305,000 in the current year-to-date period compared to the prior year-to-date period. The average brass price paid per pound increased to $4.15 in the current year-to-date period from $3.86 in the prior year-to-date period. During the current year-to-date period, we used approximately 670,000 pounds of brass. This resulted in increased brass costs of approximately $190,000 in the current year-to-date period compared to the prior year-to-date period.

Engineering, selling and administrative expenses were $24.9 million in the current year-to-date period compared to $24.4 million in the prior year-to-date period. The increase was primarily due to higher expense provisions for the accrual of bonuses earned under our EVA^® Incentive Bonus Plans in the current year-to-date period as compared to the prior year-to-date period.

Income from operations in the current year-to-date period was $10.9 million compared to $4.8 million in the prior year-to-date period. This change was the result of the increase in sales and gross profit margin in the current year-to-date period over the same period in the prior year as discussed above.

Equity loss of joint ventures was $452,000 during the current year-to-date period compared to equity earnings of $1.0 million in the prior year-to-date period. During the current year-to-date period our joint ventures in China and Brazil both incurred relocation costs associated with moves to new facilities and start-up costs associated with a new product line. Both of these items resulted in STRATTEC incurring an equity loss from joint ventures in the current year-to-date period compared to the prior year-to-date period in which STRATTEC had equity earnings from joint ventures. We anticipate these transition costs and related losses to continue for VAST China over the remaining 2012 calendar year.

Included in other income (expense), net in the current year-to-date period and prior year-to-date period were the following items (in thousands):


	Nine Months Ended
	April 1, 2012			March 27, 2011
Foreign Currency Transaction Gain (Loss)	$	907		$	(558	)
Rabbi Trust Gain		64			333
Unrealized Loss on Mexican Peso
Option Contracts		(542	)		(114	)
Realized Loss on Mexican Peso
Option Contracts		(236	)		—
Other		104			238

	$	297		$	(101	)

Foreign currency transaction gains and losses resulted from foreign currency transactions entered into by our Mexican subsidiaries and fluctuations in foreign currency cash balances. In September of the current fiscal year, the Mexican peso devalued significantly to the U.S. dollar creating both foreign currency transaction gains and unrealized losses on our Mexican peso currency option contracts. In the current year third quarter, the Mexican peso appreciated significantly to the U.S. dollar creating foreign currency transaction losses and unrealized gains on our Mexican peso currency option contracts, which offset a portion of the unrealized losses occurring as a result of the previously recognized peso devaluation impact. Our objective in entering into these currency option contracts was to minimize our earnings volatility resulting from changes in exchange rates affecting the U.S. dollar cost of our Mexican operations. Unrealized losses recognized as a result of mark-to-market adjustments as of April 1, 2012 totaled approximately $297,000, all of which may or may not be realized, depending upon the actual Mexican peso to U.S. dollar exchange rates experienced during the balance of the contract period. Our Rabbi Trust funds our supplemental executive retirement plan. The investments held in the Trust are considered trading securities.

Our income tax provision for each of the nine month periods ended April 1, 2012 and March 27, 2011 was impacted by a lower effective and statutory tax rate for income subject to tax in Mexico as compared to the effective and statutory tax rate for income subject to tax in the U.S.

Liquidity and Capital Resources

Our primary source of cash flow is from our major customers, which include General Motors Company, Ford Motor Company, and Chrysler Group LLC. As of the date of filing this Form 10-Q with the Securities and Exchange Commission, all of our customers are making payments on their outstanding accounts receivable in accordance with the payment terms included on their purchase orders. A summary of our outstanding receivable balances from our major customers as of April 1, 2012 was as follows (in thousands of dollars):


General Motors	$	10,986
Ford	$	4,901
Chrysler	$	13,799
Hyundai / Kia	$	1,235

We earn a portion of our operating income in Mexico, which is deemed to be permanently reinvested. As of April 1, 2012, $5.2 million of our $15.7 million cash and cash equivalents balance was held by our foreign subsidiaries in Mexico. We currently do not intend nor foresee a need to repatriate these funds. We expect existing domestic cash and cash equivalents and cash flows from operations to continue to be sufficient to fund our operating activities and cash commitments for investing and financing activities, such as regular quarterly dividends and capital expenditures, for at least the next 12 months and thereafter for the foreseeable future.

Should we require more capital in the U.S. than is generated by our operations domestically, for example to fund significant discretionary activities, such as acquisitions of businesses and share repurchases, we could elect to repatriate future earnings from foreign jurisdictions or raise capital in the U.S. through borrowings under our revolving credit facility. These alternatives could result in higher effective tax rates, increased interest expense, or other dilution of our earnings.

Cash flow provided by operating activities was $9.9 million during the nine months ended April 1, 2012 compared to cash flow used in operating activities of $308,000 during the nine months ended March 27, 2011. The change in cash flow provided by operating activities was primarily attributable to an improvement in our overall financial results and reduced working capital requirements in the current year period as compared to the prior year period. Net income adjusted for non-cash items such as depreciation, unrealized losses on foreign currency contracts and foreign currency transaction gains and losses increased approximately $4.5 million in the current year-to-date-period as compared to the prior year-to-date period. Cash used for working capital requirements decreased approximately $5.7 million between periods in the current year-to-date-period as compared to the prior year-to-date period. The working capital requirements during the prior year-to-date period were impacted by a significant increase in accounts receivable and inventory resulting from significantly increased sales levels during that period. Current period operating cash flow was impacted by an August 2011 payment of approximately $4.3 million in bonuses, which were earned during fiscal 2011 under our incentive bonus plans. Bonus payments totaled approximately $5 million in the prior year-to-date period. Prior year period operating cash flow was also impacted by an increase in accounts receivable of $6.3 million, which resulted from increased sales during that period. Pension contributions to our qualified plan totaled $1.5 million during both the current year-to-date period and prior year-to-date period.

During the nine months ended April 1, 2012, our portion of capital contributions made to VAST LLC in support of general operating expenses totaled $200,000. During the current year-to-date period the VAST joint ventures in China and Brazil both incurred relocation costs associated with moves to new facilities and start-up costs associated with a new product line. These relocation costs and start-up costs have been financed internally by VAST LLC. We anticipate these transition costs and related losses to continue for VAST China over the remaining 2012 calendar year. In addition, we anticipate that VAST China capital expenditures will be approximately $8 million to $9 million during calendar year 2012 (which includes a portion of our fiscal 2012 and fiscal 2013) in support of the new product line and new product programs. As a result, we estimate that our portion of additional capital contributions to VAST LLC could be $1 million to $2 million during the remainder of the current fiscal year.

Capital expenditures during the current year-to-date period totaled $9.6 million compared to $5.7 million in the prior year-to-date period. We anticipate that capital expenditures will be approximately $11 million in fiscal 2012, primarily relating to expenditures in support of requirements for new product programs and the upgrade and replacement of existing equipment.

On February 26, 2009, our Board of Directors took action to suspend payment of our $0.15 per common share quarterly dividend to conserve cash. On August 4, 2010, our Board of Directors declared a special one-time cash dividend of $1.20 per common share payable on October 29, 2010. The special dividend totaled approximately $4.0 million and was funded with current cash balances. Although we believe the outlook for our business is generally positive, the uncertain strength of the economic recovery in North America, and the effect that this and the recent restructuring of our two largest customers may have on STRATTEC have resulted in both management and our Board being cautious about reinstating our regular quarterly cash dividend at the rate in place prior to the dividend suspension. However, our Board of Directors, on August 23, 2011, did reinstate a regular quarterly cash dividend at a level of $0.10 per common share. A quarterly cash dividend of $0.10 per common share was paid on each of September 30, 2011, December 30, 2011, and March 30, 2012. Each quarterly dividend totaled approximately $335,000, and is expected to equal approximately $1.4 million annually, all of which was and is expected to be funded by current cash balances.

Our Board of Directors has authorized a stock repurchase program to buy back outstanding shares of our common stock. Shares authorized for buy back under the program totaled 3,839,395 at April 1, 2012. A total of 3,655,322 shares have been repurchased over the life of the program through April 1, 2012, at a cost of approximately $136.4 million. No shares were repurchased during the three or nine month periods ended April 1, 2012. Additional repurchases may occur from time to time and are expected to continue to be funded by cash flow from operations and current cash balances. Based on the current economic environment and our preference to conserve cash for other uses, we do not anticipate any stock repurchase activity for the remainder of fiscal year 2012.

We have a $25 million secured revolving credit facility (“Credit Facility”) with BMO Harris Bank N.A. The Credit Facility expires August 1, 2014. Interest on borrowings under the Credit Facility is at varying rates based, at our option, on the London Interbank Offering Rate plus one percent or the bank’s prime rate. The Credit Facility contains a restrictive financial covenant that requires us to maintain a minimum net worth level. There were no outstanding borrowings under the Credit Facility at April 1, 2012 or March 27, 2011. We had no borrowings under any third party debt facilities during the nine months ended April 1, 2012 or March 27, 2011. We believe that the Credit Facility is adequate, along with existing cash balances and cash flow from operations, to meet our anticipated capital expenditure, working capital, dividend and operating expenditure requirements.

Over the past several years, we have been impacted by rising health care costs, which have increased our cost of associate medical coverage. A portion of these increases have been offset by plan design changes and associate wellness initiatives. We have also been impacted by increases in the market price of zinc and brass and inflation in Mexico, which impacts the U. S. dollar costs of our Mexican operations. We have negotiated raw material price adjustment clauses with certain, but not all, of our customers to offset some of the market price fluctuations in the cost of zinc. Moreover, beginning in January 2011, we entered into agreements with Bank of Montreal that provide for two weekly Mexican peso currency option contracts for a portion of our weekly estimated peso denominated operating costs. Current contracts with Bank of Montreal extend through June 28, 2013. The two weekly option contracts are for equivalent notional amounts. The contracts that are currently effective and expire July 6, 2012 provide for the purchase of Mexican pesos at a U.S. dollar / Mexican peso exchange rate of 11.85 if the spot rate at the weekly expiry date is below 11.85 or for the purchase of Mexican pesos at a U.S. dollar / Mexican peso exchange rate of 12.85 if the spot rate at the weekly expiry date is above 12.85. Additional contracts that are effective July 6, 2012 through June 28, 2013 provide for the purchase of Mexican pesos at an average U.S. dollar / Mexican peso exchange rate of 12.40 if the spot rate at the weekly expiry date is below an average of 12.40 or for the purchase of Mexican pesos at an average U.S. dollar / Mexican peso exchange rate of 13.40 if the spot rate at the weekly expiry date is above an average of 13.40. Our objective in entering into these currency option contracts is to minimize our earnings volatility resulting from changes in exchange rates affecting the U.S. dollar cost of our Mexican operations. The Mexican peso option contracts are not used for speculative purposes and are not designated as hedges, and as a result, all currency option contracts are recognized in our accompanying condensed consolidated financial statements at fair value and changes in the fair value of the currency option contracts are reported in current earnings as part of Other Income (Expense), net. The premiums to be paid and received under the weekly Mexican peso currency option contracts net to zero, and as a result, premiums related to the contracts did not impact our earnings.

The following table quantifies the outstanding Mexican peso currency option contracts as of April 1, 2012 (thousands of dollars):


								Foreign Exchange Gain/(Loss) From:
	Notional Amount		Average Option Contractual Exchange Rate		Fair Value			10% Appreciation of U.S. Dollar			10% Depreciation of U.S. Dollar
Contracts Effective April 2, 2012
– July 6, 2012
Buy MXP/Sell USD	$	3,785		11.85	$	2		$	(2	)	$	126
Buy MXP/Sell USD	$	3,785		12.85	$	(73	)	$	(280	)	$	62
Contracts Effective July 6, 2012
– June 28, 2013
Buy MXP/Sell USD	$	10,200		12.40	$	176		$	(146	)	$	654
Buy MXP/Sell USD	$	10,200		13.40	$	(402	)	$	(461	)	$	198

The fair market value of all outstanding Mexican peso option contracts in the accompanying Condensed Consolidated Balance Sheets was as follows (thousands of dollars):


	April 1, 2012			July 3, 2011
Not Designated as Hedging Instruments:
Other Current Assets:
Mexican Peso Option Contracts	$	—		$	245
Other Current Liabilities:
Mexican Peso Option Contracts	$	(212	)	$	—
Other Long-Term Liabilities
Mexican Peso Option Contracts	$	(85	)	$	—


	Other Income (Expense), net
	Three Months Ended						Nine Months Ended
	April 1, 2012			March 27, 2011			April 1, 2012			March 27, 2011
Not Designated as Hedging Instruments:
Realized Gain	$	—		$	—		$	18		$	—
Realized (Loss)	$	(48	)	$	—			(254	)	$	—
Unrealized Gain (Loss)	$	1,174		$	(114	)		(542	)	$	(114	)

Joint Ventures

We participate in certain Alliance Agreements with WITTE Automotive (“WITTE”) and ADAC Automotive (“ADAC”). WITTE, of Velbert, Germany, is a privately held automotive supplier. WITTE designs, manufactures and markets automotive components, including locks and keys, hood latches, rear compartment latches, seat back latches, door handles and specialty fasteners. WITTE’s primary market for these products has been Europe. ADAC, of Grand Rapids, Michigan, is a privately held automotive supplier and manufactures engineered products, including door handles and other automotive trim parts, utilizing plastic injection molding, automated painting and various assembly processes.

The Alliance agreements include a set of cross-licensing agreements for the manufacture, distribution and sale of WITTE products by STRATTEC and ADAC in North America, and the manufacture, distribution and sale of STRATTEC and ADAC products by WITTE in Europe. Additionally, a joint venture company, Vehicle Access Systems Technology LLC (“VAST LLC”), in which WITTE, STRATTEC and ADAC each hold a one-third interest, exists to seek opportunities to manufacture and sell the companies’ products in areas of the world outside of North America and Europe.

VAST do Brasil, a joint venture between VAST LLC and Ifer do Brasil Ltda., services customers in South America. VAST Fuzhou, VAST Great Shanghai and VAST Shanghai Co. (collectively known as VAST China), provides a base of operations to service our automotive customers in the Asian market. VAST LLC also maintains branch offices in South Korea and Japan in support of customer sales and engineering requirements.

The VAST LLC investments are accounted for using the equity method of accounting. The activities related to the VAST LLC joint ventures resulted in equity loss of joint ventures to STRATTEC of approximately $452,000 during the nine months ended April 1, 2012 and equity earnings of joint ventures to STRATTEC of approximately $1.0 million during the nine months ended March 27, 2011. Effective November 20, 2009, VAST LLC purchased the 40 percent non-controlling interest owned by its former partners in the joint ventures in China. Initially, a loan of $2.5 million was made from each partner, STRATTEC, WITTE and ADAC, to fund a portion of the purchase price. In December 2009, $1 million of each partner’s loan balance was repaid. As of March 30, 2012, each partners’ outstanding principal and accrued interest under the loan totaled $1.5 million and $112,000, respectively. These outstanding amounts were terminated and automatically converted to additional capital contributions by each partner in VAST LLC effective as of March 30, 2012. During the nine months ended April 1, 2012, cash capital contributions totaling $600,000 were made to VAST LLC in support of general operating expenses. STRATTEC’s portion of the cash capital contributions totaled $200,000. During the nine months ended March 27, 2011, cash capital contributions totaling $450,000 were made to VAST LLC in support of general operating expenses. STRATTEC’s portion of the cash capital contributions totaled $150,000.

In fiscal year 2007, we entered into a joint venture with ADAC forming ADAC-STRATTEC LLC, a Delaware limited liability company. The joint venture was created to establish injection molding and door handle assembly operations in Mexico. STRATTEC originally held a 50.1 percent interest in ADAC-STRATTEC LLC. Effective June 28, 2010, STRATTEC purchased an additional .9 percent interest from ADAC and now owns 51 percent. A Mexican entity, ADAC-STRATTEC de Mexico, exists and is wholly owned by ADAC-STRATTEC LLC. ADAC-STRATTEC LLC’s financial results are consolidated with the financial results of STRATTEC and resulted in increased net income to STRATTEC of approximately $1.1 million during the nine months ended April 1, 2012 and approximately $497,000 during the nine months ended March 27, 2011.

Effective November 30, 2008, STRATTEC established a new entity, STRATTEC POWER ACCESS LLC (“SPA”), which is 80 percent owned by STRATTEC and 20 percent owned by WITTE. SPA operates the North American portion of the Power Products business which was acquired from Delphi Corporation. The financial results of SPA are consolidated with the financial results of STRATTEC and resulted in increased net income to STRATTEC of approximately $1.7 million during the nine months ended April 1, 2012 and approximately $1.8 million during the nine months ended March 27, 2011.

Other Matters

Health care reform legislation was recently enacted by the Federal government. We are currently evaluating the legislation to determine its effect on our plan structure, future operating results and financial position.

Critical Accounting Policies

The Company believes the following represents its critical accounting policies:

Pension and Postretirement Health Benefits – Pension and postretirement health obligations and costs are developed from actuarial valuations. The determination of the obligation and expense for pension and postretirement health benefits is dependent on the selection of certain assumptions used by actuaries in calculating such amounts. Those assumptions are described in the Notes to Financial Statements in our 2011 Annual Report and include, among others, the discount rate, expected long-term rate of return on plan assets, retirement age and rates of increase in compensation and health care costs. We evaluate and update all of the assumptions annually on June 30, the measurement date. Actual results that differ from these assumptions are deferred and, under certain circumstances, amortized over future periods. While we believe that the assumptions used are appropriate, significant differences in the actual experience or significant changes in the assumptions may materially affect our pension and postretirement health obligations and future expense related to these obligations. Refer to the discussion of Critical Accounting Policies included in the Management’s Discussion and Analysis and Retirement Plans and Postretirement Costs included in the Notes to Financial Statements in our 2011 Annual Report filed with the Securities and Exchange Commission as an exhibit to our Form 10-K on September 8, 2011.

Other Reserves – We have reserves such as an environmental reserve, a warranty reserve, an incurred but not reported claim reserve for self-insured health plans, an allowance for doubtful accounts related to trade accounts receivable, an excess and obsolete inventory reserve and a repair and maintenance supply parts reserve. These reserves require the use of estimates and judgment with regard to risk exposure, ultimate liability and net realizable value.

Environmental Reserve – We have a liability recorded related to the estimated costs to remediate an environmental contamination site at our Milwaukee facility, which was contaminated by a solvent spill from a former above ground solvent storage tank occurring in 1985. The recorded environmental liability balance involves judgment and estimates. Our reserve estimate is based on a third party assessment of the costs to adequately cover the cost of active remediation of the contamination at this site. Actual costs might vary from this estimate for a variety of reasons, including changes in laws and changes in the assessment of the level of remediation actually required at this site. Therefore, future changes in laws or the assessment of the level of remediation required could result in changes in our estimate of the required liability. Refer to the discussion of Commitments and Contingencies included in the Notes to Financial Statements in our 2011 Annual Report filed with the Securities and Exchange Commission as an exhibit to our Form 10-K on September 8, 2011.

Warranty Reserve – We have a warranty liability recorded related to our exposure to warranty claims in the event our products fail to perform as expected, and we may be required to participate in the repair costs incurred by our customers for such products. The recorded warranty liability balance involves judgment and estimates. Our liability estimate is based on an analysis of historical warranty data as well as current trends and information, including our customers’ recent extension of their warranty programs. Actual warranty costs might vary from estimates due to the level of actual claims varying from our claims experience and estimates. Therefore, future actual claims experience could result in changes in our estimates of the required liability. Refer to the discussion of Warranty Reserve under Organization and Summary of Significant Accounting Policies included in the Notes to Financial Statements in our 2011 Annual Report filed with the Securities and Exchange Commission as an exhibit to our Form 10-K on September 8, 2011, and Risk Factors in this Form 10-Q.

Incurred But Not Reported Claim Reserve for Self-Insured Health Plans – We have self-insured medical and dental plans covering all eligible U.S. associates. The expected ultimate cost of claims incurred under these plans is subject to judgment and estimation. We estimate the ultimate expected cost of claims incurred under these plans based upon the aggregate liability for reported claims and an estimated additional liability for claims incurred but not reported. Our estimate of claims incurred but not reported is based on an analysis of historical data, current trends related to claims and health care costs and information available from the insurance carrier. Actual ultimate costs may vary from estimates due to variations in actual claims experience from past trends and large unexpected claims being filed. Therefore, changes in claims experience and large unexpected claims could result in changes to our estimate of the claims incurred but not reported liabilities. Refer to the discussion of Self Insurance and Loss Sensitive Plans under Organization and Summary of Significant Accounting Policies included in Notes to Financial Statements in our 2011 Annual Report filed with the Securities and Exchange Commission as an exhibit to our Form 10-K on September 8, 2011.

Allowance for Doubtful Accounts Related to Trade Accounts Receivable – Our trade accounts receivable consist primarily of receivables due from Original Equipment Manufacturers in the automotive industry and locksmith distributors relating to our service and aftermarket business. Our evaluation of the collectability of our trade accounts receivable involves judgment and estimates and includes a review of past due items, general economic conditions and the economic climate of the industry as a whole. The estimate of the required reserve involves uncertainty as to future collectability of receivable balances. This uncertainty is magnified by the financial difficulty recently experienced by our customers as discussed under Risk-Factors-Loss of Significant Customers, Vehicle Content, Vehicle Models and Market Share included in the Management’s Discussion and Analysis in our 2011 Annual Report filed with the Securities and Exchange Commission as an exhibit to our Form 10-K on September 8, 2011. Also, refer to the discussion of Receivables under Organization and Summary of Significant Accounting Policies included in Notes to Financial Statements in our 2011 Annual Report filed with the Securities and Exchange Commission as an exhibit to our Form 10-K on September 8, 2011.

Excess and Obsolete Production Inventory Reserve – We record a reserve for excess and obsolete production inventory based on historical and estimated future demand and market conditions. The reserve level is determined by comparing inventory levels of individual materials and parts to historical usage and estimated future sales by analyzing the age of the inventory, in order to identify specific material and parts that are unlikely to be sold. Technical obsolescence and other known factors are also considered in evaluating the reserve level. Actual future write-offs of inventory may differ from estimates and calculations used to determine reserve levels due to changes in customer demand, changes in technology and other factors. Refer to the discussion of Inventories under Organization and Summary of Significant Accounting Policies included in the Notes to Financial Statements in our 2011 Annual Report filed with the Securities and Exchange Commission as an exhibit to our Form 10-K on September 8, 2011.

Repair and Maintenance Supply Parts Reserve – We maintain an inventory of repair and maintenance parts in support of operations. The inventory includes critical repair parts for all production equipment as well as general maintenance items. The inventory of critical repair parts is required to avoid disruptions in our customers’ just-in-time production schedules due to lack of spare parts when equipment break-downs occur. Depending on maintenance requirements during the life of the equipment, excess quantities of repair parts arise. A repair and maintenance supply parts reserve is maintained to recognize the normal adjustment of inventory for obsolete and slow-moving repair and maintenance supply parts. Our evaluation of the reserve level involves judgment and estimates, which are based on a review of historical obsolescence and current inventory levels. Actual obsolescence may differ from estimates due to actual maintenance requirements differing from historical levels. This could result in changes to our estimated required reserve. Refer to the discussion of Repair and Maintenance Supply Parts under Organization and Summary of Significant Accounting Policies included in the Notes to Financial Statements in our 2011 Annual Report filed with the Securities and Exchange Commission as an exhibit to our Form 10-K on September 8, 2011.

We believe the reserves discussed above are estimated using consistent and appropriate methods. Significant changes to the assumptions could materially affect the recorded reserves.

Stock-Based Compensation – Stock-based compensation cost is measured at the grant date based on the value of the award and is recognized as expense over the vesting period of the award. Determining the fair value of stock-based awards at the grant date requires judgment, including estimating future volatility of our stock, the amount of stock-based awards that are expected to be forfeited and the expected term of awards granted. We estimate the fair value of stock options granted using the Black-Scholes option valuation model. We amortize the fair value of all awards on a straight-line basis over the vesting periods for the awards. The expected term of awards granted represents the period of time they are expected to be outstanding. We determine the expected term based on historical experience with similar awards, giving consideration to the contractual terms and vesting schedules. We estimate the expected volatility of our common stock at the date of grant based on the historical volatility of our common stock. The volatility factor used in the Black-Scholes option valuation model is based on our historical stock prices over the most recent period commensurate with the estimated expected term of the award. We base the risk-free interest rate used in the Black-Scholes option valuation model on the implied yield currently available on U.S. Treasury zero-coupon issues with a remaining term commensurate with the expected term of the award. We use historical data to estimate pre-vesting option forfeitures. We record stock-based compensation only for those awards that are expected to vest. If actual results differ significantly from these estimates, stock-based compensation expense and our results of operations could be materially impacted.

Risk Factors

We recognize we are subject to the following risk factors based on our operations and the nature of the automotive industry in which we operate:

Loss of Significant Customers, Vehicle Content, Vehicle Models and Market Share – Sales to General Motors Company, Ford Motor Company and Chrysler Group LLC represented approximately 66 percent of our annual net sales (based on fiscal 2011 results) and, accordingly, these customers account for a significant percentage of our outstanding accounts receivable. The contracts with these customers provide for supplying the customer’s requirements for a particular model. The contracts do not specify a specific quantity of parts. The contracts typically cover the life of a model, which averages approximately four to five years. Components for certain customer models may also be “market tested” annually. Therefore, the loss of any one of these customers, the loss of a contract for a specific vehicle model, a reduction in vehicle content, the early cancellation of a specific vehicle model, technological changes or a significant reduction in demand for certain key models could occur, and if so, could have a material adverse effect on our existing and future revenues and net income.

On April 27, 2009, General Motors announced certain aspects of its Revised Viability Plan including assembly plant closures and reduced production volumes for calendar year 2009 and the subsequent five years. The announcement indicated that certain vehicle brands, including Pontiac, Saturn, Hummer and Saab, would be discontinued or sold. In addition, subsequent to Chrysler LLC’s filing for Chapter 11 bankruptcy protection on April, 30 2009, they announced certain vehicle models planned for discontinuation (Jeep Commander, Jeep Compass, Jeep Patriot, Dodge Nitro, Dodge Avenger, Dodge Caliber, Dodge Durango, Dodge Dakota, Dodge Viper, Chrysler Sebring, Chrysler Aspen, etc.). Subsequently, most of the models were reaffirmed for continued production over a two to three year period, or replaced during this period. We continue to evaluate the impact these evolving plans have on our business as more details become available.

Our major customers also have significant under-funded legacy liabilities related to pension and postretirement health care obligations. The future impact of these items along with a continuing loss in our major customers’ North American automotive market share to the “New Domestic” automotive manufacturers (primarily the Japanese automotive manufacturers) and/or a significant decline in the overall market demand for new vehicles may ultimately result in severe financial difficulty for these customers, including bankruptcy. If our major customers cannot fund their operations, we may incur significant write-offs of accounts receivable, incur impairment charges or require additional restructuring actions.

Production Slowdowns by Customers – Our major customers and many of their suppliers were significantly impacted by the recession of 2008/2009. Many of our major customers instituted production cuts during our fiscal 2009 and 2010. While production subsequently increased after the cuts made in 2009, additional economic slowdowns could bring about new production cuts which could have a material adverse effect on our existing and future revenues and net income.

Financial Distress of Automotive Supply Base – During calendar years 2009 and 2010, the automotive industry conditions adversely affected STRATTEC and our supply base. Lower production levels at our major customers, volatility in certain raw material and energy costs and the global credit market crisis resulted in severe financial distress among many companies within the automotive supply base. During the above time frame, several automotive suppliers filed for bankruptcy protection or ceased operations. The potential continuation of financial distress within the supply base and suppliers’ inability to obtain credit from lending institutions may lead to commercial disputes and possible supply chain interruptions. In addition, the potential for future and/or continued adverse industry conditions may require us to take measures to ensure uninterrupted production. The continuation or worsening of these industry conditions could have a material adverse effect on our existing and future revenues and net income.

Shortage of Raw Materials or Components Supply – In the event of catastrophic acts of nature such as fires, tsunamis, hurricanes and earthquakes or a rapid increase in production demands, either we or our customers or other suppliers may experience supply shortages of raw materials or components. This could be caused by a number of factors, including a lack of production line capacity or manpower or working capital constraints. In order to manage and reduce the costs of purchased goods and services, we and others within our industry have been rationalizing and consolidating our supply base. In addition, due to the recent turbulence in the automotive industry, several suppliers have filed bankruptcy proceedings or ceased operations. As a result, there is greater dependence on fewer sources of supply for certain components and materials, which could increase the possibility of a supply shortage of any particular component. If any of our customers experience a material supply shortage, either directly or as a result of supply shortages at another supplier, that customer may halt or limit the purchase of our products. Similarly, if we or one of our own suppliers experience a supply shortage we may become unable to produce the affected products if we cannot procure the components from another source. Such production interruptions could impede a ramp-up in vehicle production and could have a material adverse effect on our business, results of operations and financial condition.

We consider the production capacities and financial condition of suppliers in our selection process, and expect that they will meet our delivery requirements. However, there can be no assurance that strong demand, capacity limitations, shortages of raw materials, labor disputes or other problems will not result in any shortages or delays in the supply of components to us.

Cost Reduction – There is continuing pressure from our major customers to reduce the prices we charge for our products. This requires us to generate cost reductions, including reductions in the cost of components purchased from outside suppliers. If we are unable to generate sufficient production cost savings in the future to offset pre-programmed price reductions, our gross margin and profitability will be adversely affected.

Cyclicality and Seasonality in the Automotive Market – The automotive market is cyclical and is dependent on consumer spending, on the availability of consumer credit and, to a certain extent, on customer sales incentives. Economic factors adversely affecting consumer demand for automobiles and automotive production, such as rising fuel costs, could adversely impact our net sales and net income. We typically experience decreased sales and operating income during the first fiscal quarter of each year due to the impact of scheduled customer plant shut-downs in July and new model changeovers during that period.

Foreign Operations – We own and operate manufacturing operations in Mexico. As discussed under “Joint Ventures”, we also have joint venture investments in Mexico, Brazil and China. As these operations continue to expand, their success will depend, in part, on our and our partners’ ability to anticipate and effectively manage certain risks inherent in international operations, including: enforcing agreements and collecting receivables through certain foreign legal systems, payment cycles of foreign customers, compliance with foreign tax laws, general economic and political conditions in these countries and compliance with foreign laws and regulations. The joint venture investments in China and Brazil are currently generating losses due to relocation costs associated with moves to new facilities and start-up costs associated with a new product line. We anticipate these transition costs and related losses to continue through the remainder of fiscal year 2012, which may result in the need for additional future capital contributions to fund the operations of these joint venture investments.

Currency Exchange Rate Fluctuations – Our sales are denominated in U.S. dollars. We have manufacturing operations in Mexico, and as a result, a portion of our manufacturing costs are incurred in Mexican pesos. Therefore, fluctuations in the U.S. dollar / Mexican peso exchange rate may have a material effect on our profitability, cash flows and financial position, and may significantly affect the comparability of our results between financial periods. Any depreciation in the value of the U.S. dollar in relation to the value of the Mexican peso will adversely affect the cost of our Mexican operations when translated into U.S. dollars. Similarly, any appreciation in the value of the U.S. dollar in relation to the value of the Mexican peso will decrease the cost of our Mexican operations when translated into U.S. dollars. As described in Derivative Instruments included in the Notes to Financial Statements contained herein, we have entered into weekly Mexican peso currency option contracts to minimize the volatility resulting from changes in the exchange rates between the U.S. dollar and the Mexican peso. There can be no assurances that the peso currency option contracts will eliminate our exchange rate risk associated with our Mexican operations.

Sources of and Fluctuations in Market Prices of Raw Materials – Our primary raw materials are high-grade zinc, brass, nickel silver, aluminum, steel and plastic resins. These materials are generally available from a number of suppliers, but we have chosen to concentrate our sourcing with one primary vendor for each commodity or purchased component. We believe our sources of raw materials are reliable and adequate for our needs. However, the development of future sourcing issues related to using existing or alternative raw materials and the global availability of these materials as well as significant fluctuations in the market prices of these materials may have an adverse affect on our financial results if the increased raw material costs cannot be recovered from our customers.

Given the significant financial impact on us relating to changes in the cost of our primary raw materials, commencing with fiscal 2008, we began quoting quarterly material price adjustments for changes in our zinc costs in our negotiations with our customers. Our success in obtaining these quarterly price adjustments in our customer contracts is dependent on separate negotiations with each customer. It is not a standard practice for our customers to include such price adjustments in their contracts. We have been successful in obtaining quarterly price adjustments in some of our customer contracts. However, we have not been successful in obtaining the adjustments with all of our customers.

Disruptions Due to Work Stoppages and Other Labor Matters – Our major customers and many of their suppliers have unionized work forces. Work stoppages or slow-downs experienced by our customers or their suppliers could result in slow-downs or closures of assembly plants where our products are included in assembled vehicles. For example, strikes by a critical supplier called by the United Auto Workers led to extended shut-downs of most of General Motors’ North American assembly plants in February 2008 and in 1998. A material work stoppage experienced by one or more of our customers could have an adverse effect on our business and our financial results. In addition, all production associates at our Milwaukee facility are unionized. A sixteen-day strike by these associates in June 2001 resulted in increased costs as all salaried associates worked with additional outside resources to produce the components necessary to meet customer requirements. The current contract with our unionized associates is effective through June 29, 2014. We may encounter further labor disruption after the expiration date of this contract and may also encounter unionization efforts in our other plants or other types of labor conflicts, any of which could have an adverse effect on our business and our financial results. Labor contracts between General Motors Company, Ford Motor Company and Chrysler Group LLC and their unionized associates under the United Auto Workers expire in September and October 2015. Labor disruptions encountered during the contract period could have an adverse effect on our business and our financial results.

Environmental and Safety Regulations – We are subject to Federal, state, local and foreign laws and other legal requirements related to the generation, storage, transport, treatment and disposal of materials as a result of our manufacturing and assembly operations. These laws include the Resource Conservation and Recovery Act (as amended), the Clean Air Act (as amended) and the Comprehensive Environmental Response, Compensation and Liability Act (as amended). We have an environmental management system that is ISO-14001 certified. We believe that our existing environmental management system is adequate for current and anticipated operations and we have no current plans for substantial capital expenditures in the environmental area. An environmental reserve was established in 1995 for estimated costs to remediate a site at our Milwaukee facility. The site was contaminated from a former above-ground solvent storage tank, located on the east side of the facility. The contamination occurred in 1985 and is being monitored in accordance with Federal, state and local requirements. We do not currently anticipate any material adverse impact on our results of operations, financial condition or competitive position as a result of compliance with Federal, state, local and foreign environmental laws or other related legal requirements. However, risk of environmental liability and changes associated with maintaining compliance with environmental laws is inherent in the nature of our business and there is no assurance that material liabilities or changes could not arise.

Highly Competitive Automotive Supply Industry – The automotive component supply industry is highly competitive. Some of our competitors are companies, or divisions or subsidiaries of companies, that are larger than STRATTEC and have greater financial and technology capabilities. Our products may not be able to compete successfully with the products of these other companies, which could result in loss of customers and, as a result, decreased sales and profitability. Some of our major customers have previously announced that they will be reducing their supply base. This could potentially result in the loss of these customers and consolidation within the supply base. The loss of any of our major customers could have a material adverse effect on our existing and future net sales and net income.

In addition, our competitive position in the North American automotive component supply industry could be adversely affected in the event that we are unsuccessful in making strategic acquisitions, alliances or establishing joint ventures that would enable us to expand globally. We principally compete for new business at the beginning of the development of new models and upon the redesign of existing models by our major customers. New model development generally begins two to five years prior to the marketing of such new models to the public. The failure to obtain new business on new models or to retain or increase business on redesigned existing models could adversely affect our business and financial results. In addition, as a result of relatively long lead times for many of our components, it may be difficult in the short-term for us to obtain new sales to replace any unexpected decline in the sale of existing products. Finally, we may incur significant product development expense in preparing to meet anticipated customer requirements which may not be recovered.

Program Volume and Pricing Fluctuations – We incur costs and make capital expenditures for new program awards based upon certain estimates of production volumes over the anticipated program life for certain vehicles. While we attempt to establish the price of our products for variances in production volumes, if the actual production of certain vehicle models is significantly less than planned, our net sales and net income may be adversely affected. We cannot predict our customers’ demands for the products we supply either in the aggregate or for particular reporting periods.

Investments in Customer Program Specific Assets – We make investments in machinery and equipment used exclusively to manufacture products for specific customer programs. This machinery and equipment is capitalized and depreciated over the expected useful life of each respective asset. Therefore, the loss of any one of our major customers, the loss of specific vehicle models or the early cancellation of a vehicle model could result in impairment in the value of these assets which may have a material adverse effect on our financial results.

Financial Industry / Credit Market Risk – The U.S. capital and credit markets experienced significant volatility and disruption during the 2008/2009 recession. In many cases this resulted in pressures on borrowers and reduced credit availability from certain issuers without regard to the underlying financial strength of the borrower or issuer. If financial market disruption and volatility occur again in the future, there can be no assurance that such conditions will not have an adverse effect on our ability to access debt and, in turn, result in a material adverse effect on our business, financial condition and results of operations.

Warranty Claims – We are exposed to warranty claims in the event that our products fail to perform as expected, and we may be required to participate in the repair costs incurred by our customers for such products. Our largest customers have recently extended their warranty protection for their vehicles. Other automotive OEMs have similarly extended their warranty programs. We are engaged in ongoing discussions with our customers regarding warranty information and potential claims. The results of these discussions could result in additional warranty charges / claims in future periods. Depending on the nature of and the volume of vehicles involved in the potential warranty claims, these charges could be material to the financial statements. The extended warranty trend may also result in higher cost recovery claims by OEMs from suppliers whose products incur a higher rate of warranty claims above an OEM derived nominal level. Historically, we have experienced relatively low warranty charges from our customers due to our commercial arrangements and improvements in the quality, reliability and durability of our products. Due to our largest customers’ extension of their warranty protection programs and demands for higher warranty cost sharing arrangements from their suppliers, including STRATTEC, we increased our provision to cover warranty exposures during fiscal years 2010, 2011 and 2012. Moreover, in 2011, our increased warranty provision was the result of our share of the cost associated with a specific warranty claim involving a product we supplied to one of our largest customers. If our customers demand higher warranty-related cost recoveries, or if our products fail to perform as expected, it could have a material adverse impact on our results of operations and financial condition.

Item 3 Quantitative and Qualitative Disclosures About Market Risk

Our exposure to market risk is limited to fluctuations in raw material commodity prices and foreign currency exchange rate risk associated with STRATTEC’s foreign operations. We do not utilize financial instruments for trading purposes. We have not had outstanding borrowings with third parties since December 1997. There is, therefore, currently no significant exposure to market risk for changes in interest rates. To the extent that we incur future borrowings under our line of credit, we would be subject to interest rate risk related to such borrowings. We are subject to foreign currency exchange rate exposure related to the U.S. dollar costs of our manufacturing operations in Mexico. A portion of our manufacturing costs are incurred in Mexican pesos. Our earnings and cash flows are subject to fluctuations as a result of changes in the U.S. dollar / Mexican peso exchange rate. Beginning in January 2011, we entered into agreements with Bank of Montreal that provide for two weekly Mexican peso currency option contracts for a portion of our weekly estimated peso denominated operating costs. Current contracts with Bank of Montreal extend through June 28, 2013. The two weekly option contracts are for equivalent notional amounts. The contracts that are currently effective and expire July 6, 2012 provide for the purchase of Mexican pesos at a U.S. dollar / Mexican peso exchange rate of 11.85 if the spot rate at the weekly expiry date is below 11.85 or for the purchase of Mexican pesos at a U.S. dollar / Mexican peso exchange rate of 12.85 if the spot rate at the weekly expiry date is above 12.85. Additional contracts that are effective July 6, 2012 through June 28, 2013 provide for the purchase of Mexican pesos at an average U.S. dollar / Mexican peso exchange rate of 12.40 if the spot rate at the weekly expiry date is below an average of 12.40 or for the purchase of Mexican pesos at an average U.S. dollar / Mexican peso exchange rate of 13.40 if the spot rate at the weekly expiry date is above an average of 13.40. Our objective in entering into these currency option contracts is to minimize our earnings volatility resulting from changes in exchange rates affecting the U.S. dollar cost of our Mexican operations. The Mexican peso option contracts are not used for speculative purposes and are not designated as hedges, and as a result, all currency option contracts are recognized in our accompanying condensed consolidated financial statements at fair value and changes in the fair value of the currency option contracts are reported in current earnings as part of Other Income (Expense), net. The premiums to be paid and received under the weekly Mexican peso currency option contracts net to zero, and as a result, premiums related to the contracts did not impact our earnings.

The following table quantifies the outstanding Mexican peso currency option contracts as of April 1, 2012 (thousands of dollars):


	Effective Dates	Notional Amount		Average Option Contractual Exchange Rate		Fair Value
Buy MXP/Sell USD	April 2, 2012-July 6, 2012	$	3,785		11.85	$	2
Buy MXP/Sell USD	April 2, 2012-July 6, 2012	$	3,785		12.85	$	(73	)
Buy MXP/Sell USD	July 6, 2012 – June 28, 2013	$	10,200		12.40	$	176
Buy MXP/Sell USD	July 6, 2012 – June 28, 2013	$	10,200		13.40	$	(402	)

The fair market value of all outstanding Mexican peso option contracts in the accompanying Condensed Consolidated Balance Sheets was as follows (thousands of dollars):


	April 1, 2012			July 3, 2011
Not Designated as Hedging Instruments:
Other Current Assets:
Mexican Peso Option Contracts	$	—		$	245
Other Current Liabilities:
Mexican Peso Option Contracts	$	(212	)	$	—
Other Long-Term Liabilities
Mexican Peso Option Contracts	$	(85	)	$	—


	Other Income (Expense), net
	Three Months Ended						Nine Months Ended
	April 1, 2012			March 27, 2011			April 1, 2012			March 27, 2011
Not Designated as Hedging Instruments:
Realized Gain	$	—		$	—		$	18		$	—
Realized (Loss)	$	(48	)	$	—		$	(254	)	$	—
Unrealized Gain (Loss)	$	1,174		$	(114	)	$	(542	)	$	(114	)

Item 4 Controls and Procedures

We maintain disclosure controls and procedures (as defined in Rules 13a-15(e) and 15d-15(e) under the Securities Exchange Act of 1934, as amended (the “Exchange Act”)) that are designed to ensure that information required to be disclosed in the Company’s reports filed or submitted under the Exchange Act, is recorded, processed, summarized and reported within the time periods specified in the Security and Exchange Commission’s rules and forms, and that the information required to be disclosed by the Company in reports that it files or submits under the Exchange Act is accumulated and communicated to its management, including its Chief Executive Officer and Chief Financial Officer, as appropriate to allow timely decisions regarding required disclosure. As of the end of the period covered by this report, we carried out an evaluation, under the supervision and with the participation of our management, including our Chief Executive Officer and Chief Financial Officer, of the effectiveness of the design and operation of our disclosure controls and procedures. Based on this evaluation, our Chief Executive Officer and Chief Financial Officer concluded that, as of the end of such period, our disclosure controls and procedures were effective at reaching a level of reasonable assurance. It should be noted that in designing and evaluating the disclosure controls and procedures, management recognized that any controls and procedures, no matter how well designed and operated, can provide only reasonable assurance of achieving the desired control objectives, and management necessarily was required to apply its judgment in evaluating the cost benefit relationship of possible controls and procedures. We have designed our disclosure controls and procedures to reach a level of reasonable assurance of achieving the desired control objectives.

There was no change in our internal control over financial reporting (as defined in Rules 13a-15(f) and 15d-15(f) under the Exchange Act) during our most recently completed fiscal quarter that has materially affected, or is reasonably likely to materially affect, our internal control over financial reporting.

Part II

Other Information

Item 1 Legal Proceedings

In the normal course of business, we may be involved in various legal proceedings from time to time. We do not believe we are currently involved in any claim or action the ultimate disposition of which would have a material adverse effect on our financial statements.

Item 1A - Risk Factors

Please refer to the section titled “Risk Factors” herein for disclosures regarding the risks and uncertainties relating to our business. There have been no material changes to the risk factors disclosed in our Form 10-K as filed with the Securities and Exchange Commission on September 8, 2011.

Item 2 Unregistered Sales of Equity Securities and Use of Proceeds –

Issuer Purchases of Equity Securities

Our Board of Directors authorized a stock repurchase program on October 16, 1996, and the program was publicly announced on October 17, 1996. The Board of Directors has periodically increased the number of shares authorized for repurchase under the program, most recently in August 2008. The program currently authorizes the repurchase of up to 3,839,395 shares of our common stock from time to time, directly or through brokers or agents, and has no expiration date. Over the life of the repurchase program through April 1, 2012, a total of 3,655,322 shares have been repurchased at a cost of approximately $136.4 million. No shares were repurchased during the nine month period ended April 1, 2012.

Item 3 Defaults Upon Senior Securities - None

Item 4 Mine Safety Disclosures - None

Item 5 Other Information - None

Item 6 Exhibits


(a)	Exhibits

	31.1	Rule 13a-14(a) Certification for Harold M. Stratton II, Chairman and Chief Executive Officer

	31.2	Rule 13a-14(a) Certification for Patrick J. Hansen, Chief Financial Officer

	32 ⁽¹⁾	18 U.S.C. Section 1350 Certifications

	101	The following materials from STRATTEC SECURITY CORPORATION's Quarterly Report on Form 10-Q for the fiscal quarter ended April 1, 2012 formatted in XBRL (eXtensible Business Reporting Language) and furnished electronically herewith: (i) Condensed Consolidated Statements of Operations and Comprehensive Income; (ii) Condensed Consolidated Balance Sheets; (iii) Condensed Consolidated Statements of Cash Flows; and (iv) Notes to Condensed Consolidated Financial Statements*

Pursuant to Rule 406T of Regulation S-T, the Interactive Data Files in Exhibit 101 hereto are deemed not filed or part of a registration statement or prospectus for purposes of Sections 11 or 12 of the Securities Act of 1933, as amended, are deemed not filed for purposes of Section 18 of the Securities and Exchange Act of 1934, as amended, and otherwise are not subject to liability under those sections.

⁽¹⁾	This certification is not “filed” for purposes of Section 18 of the Securities Exchange Act of 1934, as amended, or incorporated by reference into any filing under the Securities Act of 1933, as amended, or the Securities Exchange Act of 1934, as amended.

SIGNATURE

Pursuant to the requirements of the Securities Exchange Act of 1934, the registrant has duly caused this report to be signed on its behalf by the undersigned thereunto duly authorized.


	STRATTEC SECURITY CORPORATION (Registrant)

Date: May 9, 2012	By	/s/ Patrick J. Hansen
		Patrick J. Hansen
		Senior Vice President,
		Chief Financial Officer,
		Treasurer and Secretary
		(Principal Accounting and Financial Officer)

EX-31.1

Exhibit 31.1

CERTIFICATION OF CHIEF EXECUTIVE OFFICER

PURSUANT TO SECTION 302 OF THE SARBANES-OXLEY ACT OF 2002

I, Harold M. Stratton II, certify that:

1. I have reviewed this quarterly report on Form 10-Q of STRATTEC SECURITY CORPORATION;

2. Based on my knowledge, this report does not contain any untrue statement of a material fact or omit to state a material fact necessary to make the statements made, in light of the circumstances under which such statements were made, not misleading with respect to the period covered by this report;

3. Based on my knowledge, the financial statements, and other financial information included in this report, fairly present in all material respects the financial condition, results of operations and cash flows of the registrant as of, and for, the periods presented in this report;

4. The registrant’s other certifying officer and I are responsible for establishing and maintaining disclosure controls and procedures (as defined in Exchange Act Rules 13a-15(e) and 15d-15(e)) and internal control over financial reporting (as defined in Exchange Act Rules 13a-15(f) and 15d-15(f)) for the registrant and have:

(a) designed such disclosure controls and procedures, or caused such disclosure controls and procedures to be designed under our supervision, to ensure that material information relating to the registrant, including its consolidated subsidiaries, is made known to us by others within those entities, particularly during the period in which this report is being prepared;

(b) designed such internal control over financial reporting, or caused such internal control over financial reporting to be designed under our supervision, to provide reasonable assurance regarding the reliability of financial reporting and the preparation of financial statements for external purposes in accordance with generally accepted accounting principles;

(c) evaluated the effectiveness of the registrant’s disclosure controls and procedures and presented in this report our conclusions about the effectiveness of the disclosure controls and procedures, as of the end of the period covered by this report based on such evaluation; and

(d) disclosed in this report any change in the registrant’s internal control over financial reporting that occurred during the registrant’s most recent fiscal quarter (the registrant’s fourth fiscal quarter in the case of an annual report) that has materially affected, or is reasonably likely to materially affect, the registrant’s internal control over financial reporting; and

5. The registrant’s other certifying officer and I have disclosed, based on our most recent evaluation of internal control over financial reporting, to the registrant’s auditors and the audit committee of registrant’s board of directors (or persons performing the equivalent functions):

(a) all significant deficiencies and material weaknesses in the design or operation of internal control over financial reporting which are reasonably likely to adversely affect the registrant’s ability to record, process, summarize and report financial information; and

(b) any fraud, whether or not material, that involves management or other employees who have a significant role in the registrant’s internal control over financial reporting.

EX-31.2

Exhibit 31.2

CERTIFICATION OF CHIEF FINANCIAL OFFICER

PURSUANT TO SECTION 302 OF THE SARBANES-OXLEY ACT OF 2002

I, Patrick J. Hansen, certify that:

1. I have reviewed this quarterly report on Form 10-Q of STRATTEC SECURITY CORPORATION;

(b) any fraud, whether or not material, that involves management or other employees who have a significant role in the registrant’s internal control over financial reporting.

EX-32

Exhibit 32

Certification of Periodic Financial Report

Pursuant to 18 U.S.C. Section 1350

Pursuant to 18 U.S.C. Section 1350, as adopted pursuant to Section 906 of the Sarbanes-Oxley Act of 2002, each of the undersigned officers of STRATTEC SECURITY CORPORATION (the “Company”) certifies that the Quarterly Report on Form 10-Q of the Company for the quarter ended April 1, 2012 fully complies with the requirements of Section 13(a) of the Securities Exchange Act of 1934 and information contained in that Form 10-Q fairly presents, in all material respects, the financial condition and results of operations of the Company.


Dated: May 9, 2012						/s/ Harold M. Stratton II
						Harold M. Stratton II,
						Chief Executive Officer

Dated: May 9, 2012						/s/ Patrick J. Hansen
						Patrick J. Hansen,
						Chief Financial Officer

This certification is made solely for purpose of 18 U.S.C. Section 1350, subject to the knowledge standard contained therein, and not for any other purpose.

Date: May 9, 2012

/s/ Harold M. Stratton II

Harold M. Stratton II,

Chief Executive Officer